Ford Focus manuals

Ford Focus Service Manual: Intermediate Shaft

Special Tool(s)

Installer, Constant Velocity Joint Boot Clamp 205-343 (T95P-3514-A)

Material
Item Specification
Constant Velocity Joint Grease (High Temperature) XG-5 WSS-M1C258-A1

Removal

  1. Remove the RH halfshaft and intermediate shaft assembly. For additional information, refer to Halfshaft — RH in this section.
  1. Position the intermediate shaft in a soft-jawed vise.
  1. NOTE:

    Do not damage the boot.

    Detach the RH front drive halfshaft from the intermediate shaft.

    • Remove the large boot clamp and slide back the boot.
    • Pull out the front drive halfshaft from the tripod housing.

Installation

  1. Install the required amount of grease in the CV joint housing.
  1. Position the tripod in the housing.
    1. Push the tripod to the bottom of the housing.
    1. Position the boot clamp on the boot.

  1. NOTICE: Use care not to damage the boot or component damage may occur.

    Install the front halfshaft.

    1. Insert a small screwdriver under the boot seat to allow the air to escape.
    1. Slide the tripod joint in as far as possible, then pull it out 20 mm (0.787 in).
    • Remove the screwdriver.

  1. Install the boot clamp using the Constant Velocity Joint Boot Clamp Installer.

  1. Install the RH halfshaft and intermediate shaft assembly. For additional information, refer to Halfshaft — RH in this section.
Crankshaft Position (CKP) Sensor
Special Tool(s) Aligner, Crankshaft Sensor 303-1417 Timing Peg, Crankshaft TDC 303-507 General Equipment 6 mm x 18 mm bolt ...

Intermediate Shaft Bearing
Special Tool(s) Puller, Bearing 205-D064 (D84L-1123-A) Removal Remove the intermediate shaft. For additional information, refer to Intermediate Shaft in this s ...

More about Ford Focus:

Ford Focus Sectioning Guidelines - General Procedures
General Equipment 3 Phase Inverter Spot Welder 254-00002 Compuspot 700F Welder 190-50080 I4 Inverter Spot Welder 254-00014 Inverter Welder with MIG Welder 254-00015 Material Item Specification Premium Undercoating ValuGardâ ...

© 2016-2024 Copyright www.ffguide.net