Ford Focus manuals

Ford Focus Service Manual: Roof Opening Panel - Removal and Installation

Ford Focus Service Manual / Body / Roof - Fixed, Leisure / Roof Opening Panel - Removal and Installation

Removal

  1. NOTE:

    Make sure the roof opening panel is in the CLOSED position.

    Remove the headliner. For additional information, refer to Section  501-05.

  1. Disconnect the 2 front and the 2 rear drain hoses from the roof opening panel.
  1. Disconnect the roof opening panel motor electrical connector.
  1. Remove the 12 bolts and the roof opening panel.
    • With the aid of an assistant, compress the legs of the roof opening panel retaining clip and lower the roof opening panel.
  1. If installing a new roof opening panel frame, transfer components as necessary.

Installation

  1. NOTE:

    The roof opening panel must be correctly located on the retaining clip before tightening the roof opening panel bolts.

    NOTE:

    Do not fully tighten the roof opening panel frame bolts at this stage.

    Compress the legs of the roof opening panel retaining clip and install the roof opening panel.
    • Loosely install the 12 bolts.
  1. Tighten the 12 roof opening panel frame bolts in the sequence shown.
    • Tighten to 9 Nm (80 lb-in).

  1. Connect the roof opening panel motor electrical connector.
  1. Connect the 2 front and the 2 rear drain hoses to the roof opening panel.
  1. Install the headliner. For additional information, refer to Section  501-05.
  1. Initialize the roof opening panel motor. For additional information, refer to Roof Opening Panel Motor Initialization in this section.
Roof Opening Panel - Description and Operation
The roof opening panel consists of the following components: Air deflector Roof opening panel control switch Roof opening panel drain hoses Roof opening panel frame Roof opening panel ...

Roof Opening Panel Glass
Removal NOTE: The roof opening panel motor must be initialized when repairs are carried out on any part of the roof opening panel system, including: whenever the roof opening panel motor has bee ...

More about Ford Focus:

Ford Focus Engine compartment overview - 1.4L Duratec-16V (Sigma)/1.6L Duratec-16V (Sigma)/1.6L Duratec-16V Ti-VCT (Sigma)
A. Screen washer fluid reservoir*: See Washer fluid check. B. Engine coolant reservoir*: See Engine coolant check. C. Brake and clutch fluid reservoir (right-hand drive)*: See Brake and clutch fluid check. D. Engine oil filler cap*: See Engine oil check. E. Brake and clutch fluid reservoir ( ...

© 2016-2019 Copyright www.ffguide.net